CALL US

+86 17838360708

Concrete Cement Substitutes GGBS PFA and more

Concrete Cement Substitutes GGBS PFA and more

Aggregates market investigation: GGBS/PFA working paper

2014-3-19  with PFA was a suitable substitute for blended cement produced using GGBS. 14. A cement importer told us that PFA had lower cementitious properties than GGBS, but was more widely available,...

get price

Which of the following cement replacement material is ...

2010-8-27  In particular, GGBS is considered to be more compatible with renewable energy source objectives. The replacement level of GGBS can be as high as 70% of cement, which is about twice as much of PFA (typically replacement level is 40%). Hence, partial replacement of GGBS can enable higher reduction of cement content.

get price

Effects of PFA and GGBS on Early-Ages Engineering ...

PC by PFA or GGBS resulted in longer setting times but better workability with PFA exhibiting more prominent effect than GGBS. As the replacement level increased, the setting of both PFA and GGBS pastes further delayed but workabil-ity of concrete was enhanced. PFA concretes exhibited consistently lower compression and splitting tensile strengths

get price

Alternative Cement substitutes materials - Constro Facilitator

2019-10-12  Very occasionally, it can be found up to a ratio of 90% GGBS and 10% Pc. Concrete made with GGBS cement sets more slowly than concrete made with ordinary Portland cement, depending on the amount of GGBS in the cement mix, but also continues to gain strength over a longer period leading to improved overall durability and life expectancy.

get price

Sustainable Studies on Concrete with GGBS As a

performance of GGBS and the effect of GGBS on fresh concrete and hardened concrete. GGBS concrete is characterized by high strength, lower heat of hydration and resistance to chemical corrosion. EXPERIMENTAL INVESTIGATION Materials Used Ordinary Portland cement, 43 Grade conforming to IS:8112-1989 was used. The specific gravity of cement was 3.15.

get price

(PDF) Durability of Concrete Containing PFA-GGBS By-products

Abstract: Ground Granulated Blast-furnace Slag (GGBS) and Pulverised Fuel Ash (PFA) were used to replace up to 60% of Portl and cement (PC) in concrete. The testing program of the concrete included...

get price

THE SORPTION AND POROSITY OF GGBS-PFA TERNARY

2019-7-10  The materials used as binder for the mix design of ternary blended concrete are Portland cement, GGBS and PFA, while fine aggregates and coarse aggregates are also added. There are two chemical admixture are used to serve as high range water reducer and high range water reducing retarder. The chemical composition of binders are showed in Table 1.

get price

The environmental impacts of concrete design, procurement ...

2000-6-12  GGBS performs better than PFA in terms of CO 2 reduction, simply due to the higher levels of substitution for cement. The values for distance travelled range from 6.72 to 18.47 miles. In this case the high cement mixes fare better because of the higher local availability of OPC compared with GGBS, PFA and lightweight aggregates.

get price

INDUSTRIAL BY-PRODUCTS AS POSSIBLE ALTERNATIVES TO GGBS ...

2019-5-21  Properties of high-strength concrete mixes containing PFA and ggbs Authors: P. L. Domone , M. N. Soutsos Source: Magazine of Concrete Research, Volume 47, Issue 173 , 1 Dec 1995 (355–367)

get price

Which of the following cement replacement material is ...

(ii) Differences Between GGBS and PFA The use of GGBS as replacement of cement enhances smaller reliance on PFA. In particular, GGBS is considered to be more compatible with renewable energy source objectives. The replacement level of GGBS can be as high as 70% of cement, which is about twice as much of PFA (typically replacement level is 40%).

get price

Sustainable Studies on Concrete with GGBS As a

performance of GGBS and the effect of GGBS on fresh concrete and hardened concrete. GGBS concrete is characterized by high strength, lower heat of hydration and resistance to chemical corrosion. EXPERIMENTAL INVESTIGATION Materials Used Ordinary Portland cement, 43 Grade conforming to IS:8112-1989 was used. The specific gravity of cement was 3.15.

get price

Readers ask: How To Make Concrete Without Cement? -

What can I use instead of cement? Concrete: Cement Substitutes . Pulverised Fuel Ash (PFA), aka ‘Fly ash’ as a cement substitute. PFA is a by-product of coal-burning power stations. Ground Granulated Blast-furnace Slag (GGBS) as a cement substitute. GGBS is a by-product of the iron and steel industry. Silica fume. Limestone fines ...

get price

Aggregates market investigation: Addendum to

2014-3-19  AGGREGATES, CEMENT AND READY-MIX CONCRETE MARKET INVESTIGATION ... production of PFA was seasonal, with more being produced in the winter months ... substitute for PFA and GGBS. 6 would equal a total PFA and limestone sales in the region of 1 million tonnes per year. 7. 10. The estimates of total PFA sales in GB that were contained in the ...

get price

Durability of Concrete Containing PFA-GGBS By-products

Durability of Concrete Containing PFA-GGBS By-products . ... in increased durability. However, blended concrete exhibited more loss in strength compared to the concrete without cement blends. ... re-use of industrial byproducts in cement and concrete has been- conducted for several decades with relative

get price

The environmental impacts of concrete design, procurement ...

2000-6-12  GGBS performs better than PFA in terms of CO 2 reduction, simply due to the higher levels of substitution for cement. The values for distance travelled range from 6.72 to 18.47 miles. In this case the high cement mixes fare better because of the higher local availability of OPC compared with GGBS, PFA and lightweight aggregates.

get price

Carbon Dioxide (CO2) Emissions of Concrete

2013-6-13  It is 3 to 4 times more expensive than times more expensive than Portland cement. v _ _ _ CeramiCreteCeramiCrete Ceramicrete concrete repair material intact and ... 2 in GGBS PFA • For C32/40 concrete mix, reduction of eCO 2 is shown through use of

get price

Effect of Replacement of GGBS and Fly Ash with Cement in ...

2020-7-3  The tests were conducted with partial replacement of GGBS at different percentages of 0, 10, 15, 20 and 25% and with FA at different percentage of 0, 5, 7.5, 10, 12.5 and 15% by the dry weight of cement. Tests on workability and compressive strength were carried out on concrete mixes prepared at different percentages of GGBS and FA.

get price

Development of an innovative one part green concrete

carbon dioxide emissions. The use of cement substitutes is an area where there is a lot of ongoing research. Geopolymer concrete is a concrete in which cement is replaced by waste materials such as Pulverised Fuel Ash (PFA), or Ground Grao activate the nulated Blast Slag (GGBS). T geopolymerisisation, an alkali activator is used.

get price

Readers ask: How To Make Concrete Without Cement? -

What can I use instead of cement? Concrete: Cement Substitutes . Pulverised Fuel Ash (PFA), aka ‘Fly ash’ as a cement substitute. PFA is a by-product of coal-burning power stations. Ground Granulated Blast-furnace Slag (GGBS) as a cement substitute. GGBS is a by-product of the iron and steel industry. Silica fume. Limestone fines ...

get price

The Use of PFA in Structural Concrete

2010-4-25  shortage of cement and the improved properties it brings to concrete all indicate that more PFA should be used as a cement replacement material. Classified PFA complying with the General Specification, or PPFAC blended cement complying with BS 6588 should be regarded not only as acceptable in all types of concrete work, but as desirable.

get price

Benefits of Sustainable Concrete Hanson UK

2021-8-10  More sustainable than other cement substitutes such as Fly Ash (PFA)* Meets criteria for sustainable construction; Using Regen can significantly reduce the embodied carbon content of concrete, making EcoPlus a more environmentally friendly concrete option.

get price

Investigating the influence of cement replacement by high ...

2019-8-15  Three mixtures were prepared with different percentages of GGBS and PFA (40%, 60% and 80%) as replacement of cement along with other mixture that made with 100% cement as a control mixture. In order to evaluate the performance of the cement mortars, compressive strength test after 7, 14 and 28 days of curing was used.

get price

Additives to Increase the Sustainability of Concrete ...

2021-3-24  consisting of PFA, GGBS, MK, SF and BPD to reduce the cement content of ... The aim of this study was to break through current limits with cement substitutes in concrete paving block and introduce high levels of cementitious constituents. As well ... particle size of more

get price

concrete applications using ggbs - perelkabiszcza

Concrete: Cement Substitutes Very occasionally, it can be found up to a ratio of 90% GGBS and 10% Pc. Concrete made with GGBS cement sets more slowly than concrete made with ordinary Portland cement, depending on the amount of GGBS in the cement mix, but also continues to gain strength over a longer period leading to improved overall durability ...

get price

Carbon Dioxide (CO2) Emissions of Concrete

2013-6-13  It is 3 to 4 times more expensive than times more expensive than Portland cement. v _ _ _ CeramiCreteCeramiCrete Ceramicrete concrete repair material intact and ... 2 in GGBS PFA • For C32/40 concrete mix, reduction of eCO 2 is shown through use of

get price

Effect of Replacement of GGBS and Fly Ash with Cement in ...

2020-7-3  The tests were conducted with partial replacement of GGBS at different percentages of 0, 10, 15, 20 and 25% and with FA at different percentage of 0, 5, 7.5, 10, 12.5 and 15% by the dry weight of cement. Tests on workability and compressive strength were carried out on concrete mixes prepared at different percentages of GGBS and FA.

get price

Development of an innovative one part green concrete

carbon dioxide emissions. The use of cement substitutes is an area where there is a lot of ongoing research. Geopolymer concrete is a concrete in which cement is replaced by waste materials such as Pulverised Fuel Ash (PFA), or Ground Grao activate the nulated Blast Slag (GGBS). T geopolymerisisation, an alkali activator is used.

get price

Effect of Micro Silica and GGBS on Compressive Strength ...

2017-3-14  cement (Concrete Society, 1991). In Europe, GGBS has been used for over 100 years. In North America, the history of the use of GGBS in quality concrete dates back about 50 years (Yazdani, 2002). In South East Asian countries including Mainland China and Hong Kong, GGBS was used in concrete in around 1990.

get price